用于柔性OLED汽车尾灯的SiN<sub>x</sub>/SiO<sub>x</sub>多层堆叠衬底

康建喜; 朱映光; 张文; 孙会兰

您当前的位置：

首页 >

文章列表页 >

用于柔性OLED汽车尾灯的SiN_x/SiO_x多层堆叠衬底

光学器件与系统设计 | 更新时间：2026-07-23

- 用于柔性OLED汽车尾灯的SiN_x/SiO_x多层堆叠衬底
- SiN_x/SiO_x multilayer stacks as flexible OLED substrates for automotive tail lights
- 光学技术 2026年52卷第4期页码：397-402
- 作者机构：
  
  1.固安翌光科技有限公司，河北廊坊 065000
  2.河北科技大学，河北省柔性功能材料重点实验室，河北石家庄 050018
- 作者简介：
  
  康建喜（1990— ），男，助理研究员，硕士，从事柔性OLED的研究。kangjx@yeolight.com
  孙会兰（1981— ），女，教授，博士，从事柔性发光材料研究。sunhuilan1949@163.com
- 基金信息：
  
  河北省科学技术厅创新能力提升计划项目(235A0601D)
- DOI：
  中图分类号： TP32
- 收稿：2026-04-02，
  
  修回：2026-05-14，
  
  录用：2026-05-22，
  
  网络首发：2026-07-23，
  
  纸质出版：2026-07-20
- 稿件说明：
移动端阅览
康建喜,朱映光,张文等.用于柔性OLED汽车尾灯的SiN_x/SiO_x多层堆叠衬底[J].光学技术,2026,52(04):397-402.

KANG Jianxi,ZHU Yingguang,ZHANG Wen,et al.SiN_x/SiO_x multilayer stacks as flexible OLED substrates for automotive tail lights[J].OPTICAL TECHNIQUE,2026,52(04):397-402.
康建喜,朱映光,张文等.用于柔性OLED汽车尾灯的SiN_x/SiO_x多层堆叠衬底[J].光学技术,2026,52(04):397-402. DOI：

KANG Jianxi,ZHU Yingguang,ZHANG Wen,et al.SiN_x/SiO_x multilayer stacks as flexible OLED substrates for automotive tail lights[J].OPTICAL TECHNIQUE,2026,52(04):397-402. DOI：

摘要

为解决柔性有机发光二极管（OLED）汽车尾灯用衬底难以兼顾高阻隔、高透光与良好弯曲性能的难题，文章采用等离子体增强化学气相沉积技术在聚酰亚胺上制备SiN

/SiO

多层堆叠衬底，系统调控堆叠周期数与沉积温度。结果表明当周期数为4、沉积温度为280℃时，水汽透过率达1.0×10

-6

g·m

-2

·day

-1

，600~650nm波段平均透过率为89.99%，10mm弯曲半径循环100次后无损伤。基于该衬底的柔性OLED在85℃、85%相对湿度、2000cd/m

下连续工作2000小时未出现失效。所开发的SiN

/SiO

多层堆叠衬底满足汽车尾灯对高环境稳定性与长寿命的严苛要求，在车载柔性照明领域具有重要应用前景。

Abstract

To address the challenge that flexible organic light-emitting diode （OLED） substrates for automotive taillights cannot simultaneously achieve high barrier property

high transparency

and good bending performance

a SiN

/SiO

multilayer stacked substrate was prepared on polyimide by plasma-enhanced chemical vapor deposition

and t

he stacking cycle number and deposition temperature were systematically tuned. The results show that with 4 cycles and a deposition temperature of 280°C

the water vapor transmission rate reaches 1.0×10

-6

g·m

-2

·day

-1

the average transmittance in the 600~650nm band is 89.99%

and no damage is observed after 100 bending cycles at a radius of 10 mm. Flexible OLED fabricated on this substrate exhibit no failure after continuous operation for 2000 h under conditions of 85°C

85% relative humidity

and 2000cd/m

. The developed SiN

/SiO

multilayer stacked substrate meets the stringent requirements of automotive taillights for high environmental stability and long lifetime

showing significant application prospects in vehicle-mounted flexible lighting.

关键词

Keywords

references

Xu Mengxin , Han Meina , Xue Minying , et al . High-performance flexible near-infrared organic light-emitting diodes with a heterogeneous alloy semitransparent electrode [J ] . Advanced Materials , 2026 , 38 （ 17 ）: e18212 .

Lu Zhen , Huang Jiaming , Liang Qiong , et al . Intrinsically stretchable organic light-emitting-diode with high brightness and stretchability via elastic-microphase-engineered emitter and dual-embedded electrode [J ] . Light-Science & Applications , 2026 , 15 （ 1 ）: 182 .

曹卫卫 , 孙逊 , 安双新 , 等 . 一种用于OLED屏疵病检测的高解析度线扫描镜头设计 [J ] . 光学技术 , 2021 , 47 （ 02 ）: 163 — 166 .

Cao Weiwei , Sun Xun , An Shuangxin , et al . Lens design of high resolution line scan for oled screen defect detection [J ] . Optical Technique , 2021 , 47 （ 02 ）: 163 — 166 .

Yao Lanqian , Qin Yue , Li Xiangchun , et al . High-efficiency stretchable organic light-emitting diodes based on ultra-flexible printed embedded metal composite electrodes [J ] . Infomat , 2023 , 5 （ 5 ）: e12410 .

金旭东 , 张磬瀚 , 严言 , 等 . 大视场dPCR检测系统中的荧光LED照明设计 [J ] . 光学技术 , 2025 , 51 （ 04 ）: 424 — 431 .

Jing Xudong , Zhang Qinhan , Yan Yan , et al . Design of the fluorescent LED illumination in a Wide-field dPCR detection system [J ] . Optical Technique , 2025 , 51 （ 04 ）: 424 — 431 .

Wang Tingting , Lu Kuankuan , Xu Zhuohui , et al . Recent developments in flexible transparent electrode [J ] . Crystals , 2021 , 11 （ 5 ）: 511 .

庄校笑 , 刘士浩 , 张乐天 , 等 . 基于Mg掺杂载流子产生层的红绿双色可调叠层OLED及其防伪应用 [J ] . 发光学报 , 2026 , 47 （ 04 ）: 547 — 553 .

Zhuang Xiaoxiao , Liu Shihao , Zhang Letian , et al . Red-green color-tunable tandem OLED based on Mg-doped charge generation layer and its anti-counterfeiting applications [J ] . Chinese Journal of Luminescence , 2026 , 47 （ 04 ）: 547 — 553 .

Zhang Dongdong , Dai Hengyi , Zhang Hai , et al . Stable deep-blue organic light-emitting diodes based on sensitized fluorescence [J ] . Nature Photonics , 2026 , 20 （ 2 ）: 136 — 150 .

Li Mingliang , Liu Ming , Qi Feng , et al . Self-assembled monolayers for interfacial engineering in solution-processed thin-film electronic devices: Design, fabrication, and applications [J ] . Chemical Reviews , 2024 , 124 （ 5 ）: 2138 — 2204 .

于宏宇 , 张宝文 , 陈平 , 等 . 利用叠层结构提高近紫外有机发光二极管的电致发光效率与稳定性 [J ] . 发光学报 , 2025 , 46 （ 2 ）: 315 — 325 .

Yu Hongyu , Zhang Baowen , Chen Pin , et al . Boosting electroluminescence efficiency and stability of near ultraviolet organic light-emitting diodes by using tandem structure [J ] . Chinese Journal of Luminescence , 2025 , 46 （ 2 ）: 315 — 325 .

王楠 , 王波文 , 颜凯 , 等 . 基于蓝绿双波长EP-LED背光的智能LCD三百色域切换显示系统 [J ] . 光学技术 , 2026 , 52 （ 01 ）: 75 — 79 .

Wang Nan , Wang Bowen , Yan Kai , et al . Intelligent LCD three hundred color gamut switching display system based on blue-green dual wavelength EP-LED backlight [J ] . Optical Technique , 2026 , 52 （ 01 ）: 75 — 79 .

Jiang Xueshuang , Chen Kaijin , Li Chuying , et al . Ultralow coefficient of thermal expansion and a high colorless transparent polyimide film realized through a reinforced hydrogen-bond network by in situ polymerization of aromatic polyamide in colorless polyimide [J ] . ACS Applied Materials & Interfaces , 2023 , 15 （ 35 ）: 41793 — 41805 .

Nishiyama H , Yamada T , Nakabayashi M , et al . Photocatalytic solar hydrogen production from water on a 100-m 2 scale [J ] . Nature , 2021 , 598 （ 7880 ）: 304 — 307 .

Mariello M , Allmen M , Wu Kangling , et al . Hermetic, hybrid multilayer, sub-5µm-thick encapsulations prepared with vapor-phase infiltration of metal oxides in conformal polymers for flexible bioelectronics [J ] . Advanced Functional Materials , 2024 , 34 （ 41 ）: 2403973 .

Xu Yiming , Chang Guofeng , Fan Ruijia , et al . Effects of various operating conditions and optimal ionomer-gradient distribution on temperature-driven water transport in cathode catalyst layer of PEMFC [J ] . Chemical Engineering Journal , 2023 , 451 : 138924 .

钟超 , 胡海龙 , 郭太良 , 等 . 量子点微显示技术的发展与挑战 [J ] . 中国激光 , 2025 , 52 （ 5 ）: 201 — 220 .

Zhong Chao , Hu Hailong , Guo Tailiang , et al . Developments and challenges in quantum dot micro-display technology [J ] . Chinese Journal of Lasers , 2025 , 52 （ 5 ）: 201 — 220 .

牛靖凯 , 翟帅 , 田欣 , 等 . 高辐照度下晶硅光伏电池板隐形缺陷成像系统优化 [J ] . 光学技术 , 2025 , 51 （ 3 ）: 264 — 268 .

Niu Jingkai , Zhai Shuai , Tian Xin , et al . Optimization of the imaging system for detecting invisible defects on the silicon photovoltaic modules under high irradiance level [J ] . Optical Technique , 2025 , 51 （ 3 ）: 264 — 268 .

Luo Shunhua , Liu Bohao , Hu Jinyong , et al . Foldable and wearable fabric ammonia sensor based on a polyaniline/polyacrylonitrile nanofiber for smart home applications [J ] . Analytical Chemistry , 2025 , 97 （ 18 ）: 9976 — 9984 .

刘佳 , 赵广伟 , 赵德威 . 有机多层量子阱结构的发光特性及应用的研究进展 [J ] . 光子技术 , 2006 , （ 04 ）: 194 — 197 .

Liu Jia , Zhao Guangwei , Zhao Dewei . Research progress on luminescent characteristics and application of organic multilayer quantum well structure [J ] . Photon Technology , 2006 , （ 04 ）: 194 — 197 .

Dhama R , Panahpour A , Pihlava T , et al . All-optical switching based on plasmon-induced enhancement of index of refraction [J ] . Nature Communications , 2022 , 13 （ 1 ）: 3114 .

Gomes A D , Bartelt H , Frazao O . Optical vernier effect: Recent advances and developments [J ] . Laser & Photonics Rev. , 2021 , 15 （ 7 ）: 2000588 .

于润香 , 杨照清 , 薛萌 , 等 . 光学成像与拉曼探测双模态内窥镜光学系统设计 [J ] . 光学技术 , 2025 , 51 （ 03 ）: 276 — 281 .

Yu Runxiang , Yang Zhaoqing , Xue Meng , et al . Design of dual-modality optical imaging and Raman detection endoscope optical system [J ] . Optical Technique , 2025 , 51 （ 03 ）: 276 — 281 .

Gu Yue , Duan Wenyan , Wang Tongcai , et al . Additive manufacturing of Al 2 O 3 ceramic core with applicable microstructure and mechanical p roperties via digital light processing of high solid loading slurry [J ] . Ceramics International , 2023 , 49 （ 15 ） : 25216 — 25224 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

五波干涉全息聚合物分散液晶二维匀光膜研制

火焰水解制备石英玻璃及其羟基增量调控机制

钴掺杂钇铝石榴石透明陶瓷紫外激发荧光性能研究

基于特征解耦的自监督视线估计方法

基于DOAS技术检测痕量气体的研究综述

用于柔性OLED汽车尾灯的SiNx/SiOx多层堆叠衬底

SiNx/SiOx multilayer stacks as flexible OLED substrates for automotive tail lights

DOI：

摘要

Abstract

关键词

Keywords

references

用于柔性OLED汽车尾灯的SiN_x/SiO_x多层堆叠衬底

SiN_x/SiO_x multilayer stacks as flexible OLED substrates for automotive tail lights